Product ID:COLD DIP CLENR, 00006550
MSDS Date:05/31/1989
FSC:7930
NIIN:00N038658
MSDS Number: BRFFS

VALVOLINE INC

LEXINGTON, KY 40512
US

Emergency Phone: 800-274-5263

Info Phone: 606-264-7000

Cage: GO029

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

STODDARD SOLVENT; (ALIPHATIC PETROLEUM DISTILLATES)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 85-100%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

CLEAN-UP HAS BEEN COMPLETED. STOP SPILL AT

RTECS: 9999999ZZ

SALVAGE TANK. REMAINING LIQ MAY BE TAKEN UP ON SAND,

RTECS: 9999999ZZ

INTO CNTNRS. PVNT RUN-OFF TO SEWERS, STREAMS/OTHER

RTECS: 9999999ZZ

AS REQUIRED, THAT A SPILL HAS OCCURED.

RTECS: 9999999ZZ

MAY BE DEPOSITED IN LANDFILL I/A/W LOC,

RTECS: 9999999ZZ

&/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN

RTECS: 9999999ZZ

(SEE YOUR SAFETY EQUIP SUPPLIER).

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CAN CAUSE SEV IRRIT,
REDNESS, TEARING, BLURRED VISION. SKIN:PRLNG/RPTD CONT CAN CAUSE
MOD IRRIT, DEFAT, DERM. INHAL:EXCESS INHAL OF VAPS CAN CAUSE NASAL
& RESP IRRIT, CNS EFTS INCL DIZZ, WE AK, FATG, NAUS, HDCH & POSS
UNCON & EVEN DEATH. INGEST:CAN CAUSE GI IRRIT, NAUS, VOMIT & DIARR.
ASPIR (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF MATL INTO LUNGS CAN CAUSE CHEM
PNEUM WHICH CAN BE FATAL. CHRONIC:OVEREXP TO THIS MATL (OR ITS
COMPONENTS) HAS BEEN SUGGESTED AS A CAUSE OF FOLLOWING EFTS IN
HUMANS: CNS EFFECTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:SKIN:THORO WASH EXPOSED AREA W/SOAP & WATER. REMOVE & LAUNDER
CONTAM CLTHG BEFORE RE-USE. EYES:FLUSH W/LG AMTS OF WATER FOR AT
LST 15 MINS, LIFTING UPPER & LOWER LIDS OCCAS, GET MED ATTN.
INGEST:DO NO T INDUCE VOMIT, KEEP PERS WARM, QUIET &GET MED ATTN.
ASPIR OF MATL INTO LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUM WHICH
CAN BE FATAL. INHAL:REMOVE INDIVIDUAL TO FRESH AIR. IF BRTHG IS
DFCLT, (SUPDAT)

Flash Point:>105F,>41C
Lower Limits:1%
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
. WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS
ENDANGER LIFE OF FIREFIGHTER, ESP IF (SUPDAT)
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM (EVEN EMPTY) BECAUSE PROD (EVEN JUST RESIDUE) CAN IGNITE
EXPLOSIVELY. VAPS ARE HVR/AIR & MAY TRAVEL ALONG (SUPDAT)

Spill Release Procedures:SM SPILL:ABSORB LIQ ON PAPER, VERMICULITE,
FLOOR ABSORB/OTHER ABSORB MATL & TRANSFER TO HOOD. LG SPILL:ELIM
ALL IGNIT SOURCES (FLARES, FLAMES INCL PILOT LIGHTS, ELEC SPKS).
PERS NOT WEARING PROT EQUIP SHLD BE EXCLUDED FROM AREA OF SPILL
UNTIL (ING 2)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:COMBUST LIQ & VAP. KEEP AWAY FROM HEAT
& OPEN FLAME. USE/STORE ONLY W/ADEQ VENT. MAINTAIN AMBIENT AIR
CONC(S) BELOW PELS. FOR INDUSTRIAL USE ONLY.
Other Precautions:AVOID CONT W/EYES & PRLNG/RPTD CONT W/SKIN. DO NOT
TRANSFER TO UNLABELED CNTNR. DO NOT USE CUTTING/WELDING TORCH ON
CNTNR (EVEN EMPTY). CNTNRS OF THIS MATL MAY BE HAZ WHEN EMPTIED.
SINCE EMPTY CNTNRS RETAIN PROD RESIDUES (VAP, LIQ (ING 7)

Respiratory Protection:F WORKPLACE EXPOS LIM(S) OF PROD/ANY COMPONENT
IS EXCEEDED, NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN
ABSENCE OF PROPER ENVIRON CTL. OSHA REGS ALSO PERMIT OTHER
NIOSH/MSHA APPRVD RESPS (NEG PR ESS TYPE) UNDER SPECIFIED CNDTNS
(ING 8)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL &/OR LOCAL) VENT TO
MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NITRILE RUBBER OR NEOPRENE GLOVES.
Eye Protection:CHEMICAL SPLASH GOGGLES.
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:MINIMIZE EXPOSURE THROUGH GOOD HYGIENIC
PRACTICES.
Supplemental Safety and Health
FIRE FIGHT PROC:SPRAYED INTO CNTNRS OF HOT, BURNING LIQ. EXPLO
HAZ:GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER
FLAMES & IGNIT SOURCES AT LOCATIONS DIST FROM MATL HNDLG POINT.
FIRST AID PROC:ADMIN OXYGEN. IF BRTHG HAS STOPPED GIVE ARTF RESP.
KEEP PERS WARM, QUIET & GET MED ATTN.

Boiling Pt:B.P. Text:300F,149C
Vapor Pres:2 @ 20C
Vapor Density:4.9
Spec Gravity:0.78-0.785
Evaporation Rate & Reference:70 (ETHER=1)
Appearance and Odor:CLEAR, HOMOGENOUS SOLUTION, LIQUID.
Percent Volatiles by Volume:85-100

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT W/STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:MAY FORM TOXIC MATERIALS: CARBON
DIOXIDE & CARBON MONOXIDE, VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:SM SPILL:ALLOW VOLAT PORTION TO EVAP IN HOOD.
ALLOW SUFFICIENT TIME FOR VAPS TO COMPLETELY CLEAR HOOD DUCT WORK.
DISP OF REMAINING MATL I/A/W APPLIC REGS. DISP OF I/A/W ALL LOC,
STATE & FED REGS. LG S PILL:DESTROY BY LIQ INCIN. CONTAM ABSORB
(ING 6)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.